WaterFilter.com

Installing Retrofit and Replacement Vinyl Windows

In previous articles i explained to you how to determine whether your windows are candidates for vinyl replacement style frames or retrofit style frames. This week I'm going to explain the installation techniques for both frame styles. Let's start with the retrofit frame.

Retrofit window installation is really the easiest of all. The retrofit window already comes with an exterior trim attached. That's the flush fin that goes against the outside surface, usually stucco. Prepare the window by drilling 3/8" holes in the areas of the frame where you want to screw it in place. Normally, there will be 3 holes on each side and 3 more across the top. Don't predrill any holes in the bottom track. After removing the old panels, you want to run a heavy bead of caulk on the face of the old aluminum frame that you left in place. Then you and a helper set the bottom of the vinyl window onto the old aluminum bottom track and raise it into position. The flush fin or retrofit lip will act as a "stop" to hold the window in place. Have your helper hold the window while you go inside.

Once inside, you want to center the window in the opening. Slide the vent panel open and closed to make sure the window is plumb and level. To adjust for out of square conditions, shim the bottom right or left corner by placing a shimming material between the sill and bottom of the window frame. Once square, drive a 3" deck screw through the 3/8" holes and into the wood studs.Just seat the screw, don't overtighten. After you get the screws into the sides and top, remove the sliding panel. The bottom track should lift out. Look for drainage holes in the track and insert a thin screwdriver and lift up. Drive one screw in the bottom center, caulk around the screw head, then put the track back in place and re-install the sliding panel. Now, you want to go back outside and caulk the gap where the retrofit fin meets the exterior surface of the house. You want to have a double barrier of protection against water infiltration. Remember, you already applied a generous bead of caulk before inserting the new frame into the opening. The rest of the job is done on the inside.

First, you want to plug the 3/8" screw holes to hide the heads of the screws. We sell the hole plugs on the website. Just click on the "shop" tab to see a picture. The plugs will pop into place in the hole. The next step is to fill the gap around the new frame with R-13 Insulation. Do not use the foam insulation that comes in a can. Many manufacturers will not honor the warranty if the foam is used. Even the non expanding foams can cause the frame to distort, causing problems. Pack the insulation in tight. You might want to wear a dust mask during this procedure. Many people, myself included, are very sensitive to insulation. After the insulation is in place, you want to install trim around the inside to finish the job. You can use wood trim from the hardware store, or some other product. But in my experience, the best product is a vinyl flat trim that matches the window frame. The flat trim can also be purchased on the website under the "shop" tab, or you could try to find it from a local window contractor. Ours comes in 3 different widths, although the 1 3/4" wide piece is by far the most common. The trim has a double sided adhesive tape on the back. You cut the top and bottom first, stick them on the vinyl frame, making sure the trim goes to the drywall. This covers all the insulation and the old metal frame. Do the side pieces next. The final step is to caulk where the trim meets the walls.

Much of the installation process for a replacement frame is the same as the retrofit frame. But, there are a few differences. When you put the new window into the opening using a replacement frame, you don't have the flush fin holding the frame in place. You and your helper have to hold the frame in place while you put a screw in the top center to support the frame. Then, you can do your adjusting for a square condition. All of the procedures on the inside will be exactly the same, from hole plugs, to insulation, to trim and caulk. The outside is different. You have to apply the trim that was part of the retrofit frame. Again, I prefer the flat trim. Once again, you apply a bead of caulk to the old frame,then measure and cut the top and bottom trim pieces. Apply the adhesive part of the trim to the vinyl frame, and let the other part contact the bead of caulk. Trim all four sides, then caulk again where the trim meets the exterior material.

As you can see, it really doesn't matter if the exterior of your home is brick, stone, siding, or stucco. You can install vinyl windows without having to damage the surrounding structure. We have step by step instructional videos for sale on the website at how-to-install-windows.com. Next week we are going to start discussing sliding glass door replacement.

John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows

MORE ARTICLES:

Healthy Way To Lose Weight With Starving Yourself
The world is getting larger and larger, and I am not talking about the circumference of the planet. Many people have a weight problem, and it is becoming almost an epidemic health issue. There have been so many diets and exercise plans that have failed for so many people, myself included, that one begins to wonder if there is truly a healthy way to lose weight. If you?re really serious about this endeavor, you have to put the gimmicks aside and do it the old-fashioned way.

$100 Amazon Gift Certificate Could Be Yours In The Healthy Diabetic Meals Recipe Contest
HealthyDiabeticMeals.com, announces their 1st annual Healthy Diabetic Meals recipe contest. The Healthy Diabetic Meals Recipe Contest is awarding a $100 Amazon.com gift certificate to one first place winner.

Spring Garden Tips from AllAboutLawns.com Forum Help Ensure Healthy Lawns
With spring comes the start of the lawn care season, and AllAboutLawns.com offers answers to gardeners and caretakers who have specific questions about their lawns. Forum visitors can post photos and get advice from forum moderator Dawn West and other lawn enthusiasts. Proper lawn care, the identification of lawn diseases and other spring garden tips are regular topics discussed in the AllAboutLawns.com forums.

How Does A Tankless Water Heater Work?
Consider this scenario: You come home after a hard day?s work, and the only thing on your mind is taking a nice, long, hot shower. You hop in, and start to enjoy the hot water splashing down upon you. However, just a few minutes into your escape from the day, you notice the water temperature turning lukewarm. Another minute later, it is bordering on chilly. Before you know it, your nice hot shower has turned into a freezing torture test. How can this happen? Well, more than likely the problem can be traced to an underachieving storage tank water heater. For this reason (and others), more and more people are starting to discover the benefits of switching over to a tankless water heater. How does a tankless water heater work? In this article,...

Cooking And Cleaning In The Kitchen
It doesn't matter if you are fixing the sink in your kitchen or your bathroom, you can have an easy job of it or it can be a major headache. It all depends upon the valves and hoses that lead to the sink.

Concordia Launches First Integrated, Countertop Self-Serve Hot Beverage System
New Concordia Coffee Systems "Integrated Beverage System" (IBS6) produces array of flavored coffee and Chai drinks from fresh ingredients in a countertop, 2 X 2 footprint. The self-serve IBS6 caters to sophisticated hot beverage tastes and provides a contemporary employee benefit in corporate settings, while saving restaurant waitpersons the time and labor normally associated with Espresso preparation. The fully-automated unit stocks six, all-natural Torani flavors.

Drinking Water for Weight Loss
An article published in http://www.inch-aweigh.

Third World Water Treatment Systems
While Americans are taking in liter after liter of bottled water, the idea that the U.S. has bad water quality seems to be valid. All the technology that modern science has created for making our water safe has allowed us to drink fresh water any time of the day or night.

Finally: Enough Evidence to Put a Cap on Water and Plastic Bottling Industry Water Expert, Peter Goodgold, Available for Interviews to Speak on USA To
Peter Goodgold, the President of www.WaterWorks4u.com, a life-long expert in the water industry, author and speaker with extensive knowledge concerning plastic bottling practices, water contamination, water pollution, carcinogens in water, including the now proven toxic use of BPA Bisphenol A that leeches from plastic bottles into human beings, is available for television commentary and newspaper interviews on this subject.

Healthy Hair Vitamins And Minerals
Vitamins And Minerals For Healthy Hair

Sacre Bleu! Sacred and Holy Water Exclusive to AQUA TAN(R) Sunless Tanning Line
Aqua Tan, Inc. announced today that it has acquired proprietary rights to patent pending skin care products formulated with sacred and holy water. Spring water from the renowned Healing Grotto of Lourdes in the French Pyrenees, will be a new ingredient of the AQUA TAN(R) premium sunless tanning line.

How Coffee Has Changed Over The Years
Making coffee sure has changed over the years. Although it still smells the same, how we brew our coffee isn?t the same as it used to be. Many years ago, coffee was brewed on the top of a wood stove. You could smell it cooking wherever you went in your house. That is also true when you make your coffee in that type of pot on your modern range top.

Crock-Pot Cooking Tips
Crock-pot cooking can offer some very tasty meals and desserts however some basic rules should be followed when using a crock-pot to cook with. You should be careful not to over stir their food while it's cooking in a crock pot. Taking the lid off during cooking causes vast amounts of heat to escape, therefore the food should only be stirred if it is clearly stated in the recipe.

Everyone Is Drinking Gourmet Coffee
When creating decaffeinated coffee the European process involves having the beans soaked in water and washing the beans with methylene chloride. The treated beans are then dried and roasted. Gourmet coffee beans from this plant are usually harvested from this tree three times a year for 30 years.